Electrical fault light - possible causes?
- Flying John
- Site Staff
- Posts: 335
- Joined: Fri Jul 14, 2006 5:24 pm
- Location: Kent
I found that after a period of changing my driving style, it turned off. It initially lit up after a daily journey of 50-60mph dual carriageway stints.
Now I tend to keep off the dual carriageways, keeping them to less than 20% of the journey, and rarely exceeding 45mph, and the light has been off for some period of time.
This may purely be chance, though I'm reluctant to start regularly driving at high speed to test the hypothesis!
I wonder if the top speed of the vehicle isn't something that should be maintained for long periods - when I've heard of these vans failing, it's often been when they've been used daily at high speed for significant periods.
Now I tend to keep off the dual carriageways, keeping them to less than 20% of the journey, and rarely exceeding 45mph, and the light has been off for some period of time.
This may purely be chance, though I'm reluctant to start regularly driving at high speed to test the hypothesis!
I wonder if the top speed of the vehicle isn't something that should be maintained for long periods - when I've heard of these vans failing, it's often been when they've been used daily at high speed for significant periods.
It could be anything related to the insulation break down from carbon build up to battery connection, I've also wondered if it could be condensation in side one of the crates
I think the only option is to carry out an insulation check on everything with a half decent tester, I've got a tester which will go up to 1000v which should track it down just need to find the time to strip off the controller and disconnect everything and then go round and check each bit (not the controller for obviouse reasons )
ChrisB
I think the only option is to carry out an insulation check on everything with a half decent tester, I've got a tester which will go up to 1000v which should track it down just need to find the time to strip off the controller and disconnect everything and then go round and check each bit (not the controller for obviouse reasons )
ChrisB
I reject reality and substitute my own !!!!!!
ChrisB wrote:Here we go again
Couple of days of rain and damp weather and "ta da" on comes my Fault light
Suspect its a insulation fault again
Trouble is it never dam well does it in the summer when I dont mind rumaging about, noooooo it has to be raining blowing a hoooowly and cold
ChrisB
Well, water conducts...
Exactly
I also remember when changing the batteries over the cables going into the connections on the crates appeared to have a thin smear of what looked like silicon round them, which of course I never replaced, well the cable enterences appeared to have a seal on them anyway ???
ChrisB
I also remember when changing the batteries over the cables going into the connections on the crates appeared to have a thin smear of what looked like silicon round them, which of course I never replaced, well the cable enterences appeared to have a seal on them anyway ???
ChrisB
I reject reality and substitute my own !!!!!!
Joe T wrote:Mmm, is this the same dash ECU light that comes on with the ECO gauge warning light, mine flashed up this morning for the first time.
No. Check the manual, that is the light indicating that the battery is low.
The electrical fault light is the symbol of a diode with a lightning bolt (zigzag).
EVan wrote:Joe T wrote:Mmm, is this the same dash ECU light that comes on with the ECO gauge warning light, mine flashed up this morning for the first time.
No. Check the manual, that is the light indicating that the battery is low.
The electrical fault light is the symbol of a diode with a lightning bolt (zigzag).
Thanks Evan, I did have a quick look in the manual and it stated that the eco light comes on with low power reserve or temp limit reached. I was on 45% and it was quite cold this morning maybe -2.
I could not tell which warning light it was. But I guess now it was the traction battery lamp.
Thanks
Joe
Return to “Citroen Berlingo Electrique or other PSA vehicles”
Who is online
Users browsing this forum: No registered users and 12 guests